November 2019 – News Letter

Preamble

I’d planned to have something out in October, a respectable three months on from the previous issue, but life has an irritating habit of getting in the way of things. As Edmund Blackadder so eloquently put it – “The path of my life is strewn with cowpats from the Devil’s own Satanic herd”. Be assured, however, that I’ve swept up and what follows is wholly fragrant ….

Around and About the Club

Big things have been happening out on the grass of late as work has progressed steadily with building the new Carriage Shed for the raised-track riding trucks. Many cubic metres of soil have been excavated to prepare the ground for the floor-slab (6m long by 2m wide by 10cm deep) which sits several centimetres below the surrounding ground level. Four courses of blockwork are raised on this to roof-eaves level. A door-frame and sill have been fabricated in steel which occupy the full width of the track-ward end. Provision is made in the floor to bring in mains electricity.

Whilst the ground works for the carriage shed were underway, the area in front of the locomotive shed was also prepared to accommodate the new dual-gauge traverser and the slab for this was poured at the same time.

Work also continues with improvements to the track signalling and point control systems. Receiving attention now are the points between the station loop and main line so that these cannot be operated whilst a train is in transit. Additional train-detectors have been installed in the track and associated cables laid-in back to the Signal Box where a new cabinet houses the extra circuitry required.

Creosote Day, Saturday 7th September, witnessed a good turnout of willing helpers to get this annual maintenance job done. Both ground-level and raised tracks were thoroughly treated using a combination of spray-guns and brushes.

If you’ve visited the TSMEE website recently, you’ll have noticed a quite radical change in appearance and content. John Rowley has taken over the job of webmaster and is keen to stress that it is, presently, very much “work in progress”. User feedback and constructive comments are welcomed.

Events …

Open Weekend 27/28th July

This annual two-day event was not blessed with particularly good weather. It rained on-and-off on the Saturday and Sunday was dry but overcast. Nevertheless, there was a respectable turnout of both TSMEE members and visitors, the latter hailing from as far afield as Scotland, Cumbria, York and Leeds.

Visiting locomotives were :– in 3-1/2” gauge  BR “Britannia” 4-6-2, Great Central O4 2-8-0, Freelance 4-8-2 – in 5” gauge  “Chub” 0-4-0 Tank, BR Standard 4 2-6-4 Tank, NER Q6 0-8-0, NER B2 4-6-0 – and in 7-1/4” gauge  GWR 14XX 0-4-2 Tank .

Saturday lunch was Fish ‘n Chips and on Sunday our Catering Stalwarts laid on their usual splendid buffet.

Trip down the Tyne 31st August 2019

Six members joined our party on the “Fortuna” for a cruise down to Tynemouth from the Quayside in Newcastle. The weather was reasonable, even allowing for the blustery wind, and we all enjoyed the trip.

There is a full and very informative commentary on the way to Tynemouth. I have made the trip a couple of times over the years and I am amazed by the way that Tyneside industrial heritage has disappeared in a comparatively short time. It used to be the remains of ship yards, dry docks and associated industries all the way to Tynemouth. Now much of the bank-side is wooded and under modern housing. It all looks very different.

The remaining working areas are impressive and Tyne Dock is massive. The Fish Quay and Tynemouth with the Harbour Lights, like much else of the riverside, are becoming tourist attractions. That’s progress, so we all went to the bar and drank to the past.   Malcolm Phillips

Trip to see the G5 at Shildon and the P2 under construction at Darlington, 7th October 2019.

Another enjoyable day out, perhaps more related to model engineering. Volunteers at both sites were very helpful and thanks are due to Phil Work who kindly arranged tea and biscuits at Shildon.

The G5 is not quite an engine yet, but most of the parts are ready to go together. The frames, boiler, cab and plate-work just need finishing touches. The bogie for the 0-4-4 and one set of driving wheels have been finished but the crank axle has yet to arrive, as manufacture of parts and machining is all done outside. The group has been working to original plans and has had to make many patterns, some of which are placed beside the finished castings.

From Shildon we proceeded to Darlington. The P2, to be named “Prince of Wales”, is a truly impressive machine. Like the G5 it has yet to go onto its wheels, all of which have had their tyres polished to a mirror finish.  Cab and smokebox are on the frames and the boiler cladding is set up on frames beside the locomotive as the boiler is yet to come from Meiningen.

We were told about some of the technical problems – the wheel flanges have been computer designed to ease passage round curves on Heritage Railways and steam distribution will be by poppet valves.

The original Gresley design was not too successful so the designers have used the designs evolved in America after the war which were better. Boiler design has been modified by experience with Tornado and their boilers are interchangeable.

I do not know what will become of the polished wheels – one of the volunteers told me that the painters were upset because on its first trip to York of thirty miles, their beautiful paint finish was spoiled by excess grease and oil coming out of the axle boxes!

The NELPG shops were closed so we completed the trip with a visit to the Head of Steam Museum across the way from the Hopetown works. This is a nice museum with exhibits of Stockton and Darlington and NER origin. Hackworth’s “Derwent” and “Locomotion” are well displayed and there are some interesting small exhibits.   Malcolm Phillips

For your diary …

Public Running Day – Santa Special – Sunday 1st December

Christmas Tea – Sunday 22nd December

Something a bit different now – Gordon Bullard has very kindly submitted the following rather interesting article…

An Automatic Cylinder Drain-cock

Back in the 1980’s over a pie and a pint in a local hostelry, a friend and I were discussing the pros and cons of cylinder drain cocks and associated linkage to the cab of a miniature steam locomotive. 

The locomotive he was building had two sets of Stephenson’s valve gear and an axle pump between the frames, together with lubricator linkage which left little room for direct drain- cock rodding.   We discussed the possibility of automatic drain cocks and I suggested that a small inverted safety valve type of arrangement might be possible.

A set of small valves was made and fitted, each consisting of a stainless ball which was held on its seat by a small bronze spring.  The valves performed well but they looked like upside-down safety valves, which is, of course, exactly what they were.

Clearly, a horizontal arrangement was required which would be more prototypical of full sized practice. So, another set of valves was made in a tee configuration with basically the same internal arrangement but in a horizontal orientation.

These valves worked reasonably well. They certainly cleared the cylinder condensate very efficiently but for some reason when the locomotive was running slight puffs of steam were occasionally noticeable. 

Closer observation showed that one of the valves seemed to be working well with no visible leakage whilst the loco was running.  With the expectation that the poor sealing of the three sub standard valves was probable due to poor workmanship on my part,  all of the valves were disassembled for examination.

I was amazed to find that I had forgotten to put a spring in the valve that worked perfectly.  The valves were quickly reassembled without springs and found to all work perfectly.  Since then I have fitted this type of valve onto three of my locomotives with no failures.  The last loco was to LBSC’s “Maisie” design and has run on the club track on numerous occasions.  The attached drawing shows the design of the valve which is made of bar material with a silver-soldered joint.

 It took a while to work out how the valve worked without a spring.  When the locomotive is stationary any condensation in the cylinder drains down into the valve where the ball is resting on the bottom of the chamber so any water can drain away via the front hole. 

When the regulator is opened a combination of condensate and steam enters the valve where the ball is unable to seat properly due to the turbulence in the chamber.  A combination of water and steam exits the valve due to this turbulence until all of the water is displaced, which leaves the chamber full of steam which in turn forces the ball onto its seat.  It’s as simple as that.

You may well ask what the reduced diameter on the rear of the valve is for.  It is purely there to improve the fitting visually, disguising the fact that it is just a piece of simple bar material.  For members who follow full size practice and require drain piping to the locomotive’s buffer beam,  the front of the valve seat could have a small ME thread machined onto it to take a nut, nipple and associated pipe.

In conclusion, this simple valve is easy to produce, is fully automatic in operation and requires no linkage to the cab.  It would be easy to say that I had a light bulb type of moment concerning this valve’s conception but in reality it came about more by accident than design.

Drain-cocks fitted to 3-1/2″ “Maisie”

Postamble

As I remarked in the previous issue, a Newsletter requires News, and this one would have been a rather thin affair but for the contributions of Malcolm Phillips and Gordon Bullard. My thanks to them both.

Membership Subscriptions will be due for renewal at the end of the year. The cost remains at £35 Single and £45 Family. Our Treasurer Ian Spencer will take payment in cash or cheques (payable to “TSMEE Ltd”).

Brian and Friend Koppel.jpg
Brian tells all ....
K1.JPG
K1 Laser cut frames with the horn blocks fitted. The horn block cheeks are replaceable.
K2.JPG
Rear frame section assembly riveted up and trial fitted
K3.JPG
Fabricated cross members with brake shaft machined castings fitted
K4.JPG
Machined wheels with return crank set fitted
K5.JPG
Axles and split axle boxes fully machined
K6.jpeg
Axle box covers with spring lifters. An example of Ken’s ‘fag packet’ drawing to work from!
K7.jpeg
Wheels fitted to frames and the belly tank filler pipe arrangement
K8.jpeg
Coupling and connecting rods as received from CNC machining
K9.jpeg
Coupling rods with crank pin bearings prior to machining
K10.jpeg
Coupling rods fitted with reversing link
K11.jpeg
An example of the crank pin bearing securing block system
K12.jpeg
The chassis with the wheels and suspension fitted
k13.jpeg
Centre suspension spring
k14.jpeg
Centre suspension springs in situ
k15.jpeg
Rear wheel leaf spring suspension system
k16.jpeg
Machined cylinder trial dowelled to the frames
k17.jpeg
Slide valve assembly fitted to the cylinders
k18.jpeg
Cylinder and crosshead guide trial fitted
k19.jpeg
Cylinder cleading fitted with the drain cock system
k20.jpeg
Test run of chassis on air
k21.JPG
Rear wheel brake system and rods following the Engineering in Miniature drawings (from March 1999)
k22.jpeg
The mechanical brake operating gear made up
k23.JPG
The mechanical brake system assembled
k24.jpeg
The steam brake cylinder
k25.jpeg
The brake system fitted
k26.jpeg
The mechanical brake operating lever fitted
k27.jpeg
The brass well tank and associated pipework
k28.jpeg
The internal pipework system and filter
k29.JPG
Suction pipes, outlets and overflow pipe
k30.jpeg
The well tank fitted
k31.jpeg
The well tank outlet piping to the frame connections
K31A.jpeg
The silver soldered well tank filler pipes and jig
k32.jpeg
The inner fire box showing the rod stays
k33.jpeg
Rod stays and bushes
k34.jpeg
The finished boiler
k35.jpeg
The boiler on test at 200psi
k36.jpeg
Backhead water gauge fitting and fire hole door
k37.jpeg
Fountain valve system fitted and boiler crinoline attached
k38.jpeg
The crinoline framework
k39.jpeg
Kayowool lagging attached
k40.jpeg
Brass cleading all fitted
K41.jpeg
Fabricated sandbox
K42.jpeg
Regulator and N/R oil valve
K43.jpeg
The injector water inlet valves for 2 engines showing the internal components
K44.jpeg
Fabricated fountain and valves for the 3 engines courtesy of Walter Ogden
K45.jpeg
Boiler fitted with all the backhead fittings attached
K46.jpeg
Water bypass system and relief valve to and from the well tank
K47.jpeg
Right hand side pipework showing steam brake cylinder
K47A.jpeg
Double check valves for 2 of the 3 engines
k48.jpeg
Right hand side double check valve and associated pipework
K49.jpeg
Four mechanical water pumps for the 3 engines and a Polly client
K50.jpeg
The fountain, water gauge and associated pipework all fitted. The water gauge and protector were commercially produced.
K51.jpeg
The 3 steam pumps during construction
K52.jpeg
All left-hand side pipework, steam pump, lubricator and injector complete. Steam pipes were wrapped in string, held in place by superglue and painted white
K53.jpeg
Boiler safety valve bonnets
K54.jpeg
Floor fitted to frame tops
K55.jpeg
Side tank inside showing angle supports
K56.jpeg
Side tank outside showing rivet detail
K57.jpeg
Finished side tank
K58.jpeg
Hinged side tank lid
K59.jpeg
Front of cab temporarily held together with Clecos and side tanks. All parts were supplied laser cut from Polly Model Engineering
K60.jpeg
Two of the four swivel opening cab windows
K61.jpeg
Reversing lever connected
K62.jpeg
The ash pan and 3-part grate
K63.jpeg
The ash pan in place showing the release and locking mechanism
K64.jpeg
Cleading and side tanks after professional paint completed
K65.jpeg
Front and rear buffer coupling fabrications for the 3 engines
K66.jpeg
Front and rear buffer assembly prior to fitting
K67.jpeg
Finished front buffer fitted
K68.jpeg
The fitted steam pump
K69.jpeg
The finished locomotive
K70.jpeg
First run on steam in the back garden – all went well!
K71.jpeg
Steam test successfully passed at Tyneside SMEE and the first run on the track
K72.jpeg
One happy model engineer!

Contact info …

Newsletter Editor – Mike Maguire ~ mike.maguire@btinternet.com

Club Secretary – Linda Nicholls – lindanic@sky.com ~ 01 670 816072

Website – John Rowley – webmaster@tsmee.co.uk ~ 07970 164 967

For your information – a PDF copy of this News Letter can be downloaded here ….